江苏体彩网

大型吸污车的注意事项和保养 matters need attention
2016-09-19 09:24:12   来源:supamam.com   点击:

湖北新中绿专用汽车有限公司
大型吸污车顾名思义就是体积比一般的吸污车要打一些o⊙⊙ω⊙ ▼,同时由于它的动力大和装载能力大o⊙⊙ω⊙ ▼,省去力小型吸污车来回运输的时间o⊙⊙ω⊙ ▼,所以往后大型吸污车的使用效率比普通的吸污车大的多o⊙⊙ω⊙ ▼,它可以吸更多的泥浆和淤泥o⊙⊙ω⊙ ▼,更大的石头和砖块o⊙⊙ω⊙ ▼,对于这样一个我们城市环境的守卫者o⊙⊙ω⊙ ▼,我们应该更加细心的爱护和保养o⊙⊙ω⊙ ▼,让它每天都能保持良好的工作状态o⊙⊙ω⊙ ▼,同时也可以为我们创造更多的生产价值!
Large sewage suction truck suggests that the volume ratio of the general sewage suction truck to make some at the same time ⊙ ⊙︿ , because of its large power and large load capacity ⊙ ⊙︿ , small power save sewage suction truck round-trip transportation time ⊙ ⊙︿ , so the use efficiency of large sewage suction truck later than the ordinary sewage suction truck is larger ⊙ ⊙︿ , it can absorb more mud and mud ⊙ ⊙︿ , larger stones and bricks ⊙ ⊙︿ , for such a US city environment guardians ⊙ ⊙︿ , we should be more careful care and maintenance ⊙ ⊙︿ , let it every day to maintain a good working condition ⊙ ⊙︿ , but also can create more value for our production!
关于大型吸污车平时的保养和注意事项我归纳一下几点:
On the large sewage suction car usually maintenance and attention to the matter I summed up a few points:
一⊙ω⊙、润滑油:1⊙ω⊙、真空泵用普通柴机油每3天要检查补充一次;2⊙ω⊙、液压油箱里面的液压工作油每7天要检查补充一次?!-!﹏▊。
First ⊙ ⊙︿ , the lubricating oil: 1 ⊙ ⊙︿ , vacuum pump with ordinary diesel oil every 3 days to check the supplement once; 2 ⊙ ⊙︿ , the hydraulic oil tank inside the hydraulic oil every 7 days to check the supplement once.
二⊙ω⊙、传动机构的注意事项:工作前检查传动轴o⊙⊙ω⊙ ▼,联轴节等有无异常松动o⊙⊙ω⊙ ▼,要及时拎紧固定o⊙⊙ω⊙ ▼,否则会对泵及取力器和变速箱等装置造成不必要的损伤?!-!﹏▊。
Note two: the work of the transmission mechanism ⊙ ⊙︿ , check the drive shafts ⊙ ⊙︿ , couplings and other abnormal loose ⊙ ⊙︿ , timely tightening fixed ⊙ ⊙︿ , otherwise to the pump and the power take-off and transmission device to cause unnecessary damage.
三⊙ω⊙、单向伐气水分离器(双重保护装置):它是万一当罐内滿量自动停吸装置发生故障时o⊙⊙ω⊙ ▼,为防止污水进入泵内o⊙⊙ω⊙ ▼,而自动工作的双重保护装置?!-!﹏▊。吸入污泥o⊙⊙ω⊙ ▼,则易浸蚀球座和球o⊙⊙ω⊙ ▼,故要定期更换?!-!﹏▊。另外o⊙⊙ω⊙ ▼,作业时容易积存污水o⊙⊙ω⊙ ▼,所以作业结束后一定要排水和清扫浮球o⊙⊙ω⊙ ▼,并定期更换浮球?!-!﹏▊。
Three ⊙ ⊙︿ , one-way gas water separator (dual protection device): it is in case when the tank full amount of automatic shutdown device failure ⊙ ⊙︿ , to prevent the sewage into the pump ⊙ ⊙︿ , and automatic work of the dual protection device. It is easy to suck sludge ⊙ ⊙︿ , and etching tee ball ⊙ ⊙︿ , it should be changed regularly. In addition ⊙ ⊙︿ , operation easy to accumulate sewage ⊙ ⊙︿ , so after the end of job must drain and clean float ⊙ ⊙︿ , and regular replacement of the floating ball.
四⊙ω⊙、油气分离器(它能分离真空泵排出的油⊙ω⊙、水⊙ω⊙、气⊙ω⊙、混合物):分离的机油重新作为真空泵润滑油使用o⊙⊙ω⊙ ▼,但分离出的水会贮留在箱底o⊙⊙ω⊙ ▼,如油色变白o⊙⊙ω⊙ ▼,会降低润滑性和气密性?!-!﹏▊。因此应定期清扫内部o⊙⊙ω⊙ ▼,更换机油o⊙⊙ω⊙ ▼,油量在真度约93千帕时补充到量油尺下中间刻线o⊙⊙ω⊙ ▼,使用普通机械油o⊙⊙ω⊙ ▼,每月清洁一次内部?!-!﹏▊。
Four ⊙ ⊙︿ , oil and gas separator (it can separate the vacuum pump from the discharge of oil ⊙ ⊙︿ , water ⊙ ⊙︿ , gas ⊙ ⊙︿ , mixture): separation of the oil back as vacuum pump oil ⊙ ⊙︿ , but the separated water will be stored in the box ⊙ ⊙︿ , such as white oil ⊙ ⊙︿ , will reduce the lubrication and air tightness. It should be cleaned regularly ⊙ ⊙︿ , the replacement of oil ⊙ ⊙︿ , the amount of oil added to the middle line dipstick at true degree about 93 thousand PA ⊙ ⊙︿ , the use of ordinary mechanical oil ⊙ ⊙︿ , clean once a month inside.
五⊙ω⊙、后罐门夹紧装置:长期使用后o⊙⊙ω⊙ ▼,内部产生污垢o⊙⊙ω⊙ ▼,无法拧紧手轮o⊙⊙ω⊙ ▼,所以每隔3个月应铲除和清扫内部门边的污渍和铁锈o⊙⊙ω⊙ ▼,并适当补充润滑油?!-!﹏▊。
Five ⊙ ⊙︿ , after the tank door clamping device: after long-term use ⊙ ⊙︿ , internally generated dirt ⊙ ⊙︿ , to tighten the handwheel ⊙ ⊙︿ , so every 3 months should be removed and clean inside the door of the dirt and rust ⊙ ⊙︿ , and appropriate to add lubricating oil.
六⊙ω⊙、使用取力器时o⊙⊙ω⊙ ▼,离合器一定要快踩慢放o⊙⊙ω⊙ ▼,否则会损坏变速箱和取力器.
Six ⊙ ⊙︿ , the use of force ⊙ ⊙︿ , the clutch must quickly step on the slow release ⊙ ⊙︿ , otherwise it will damage the gearbox and the power of the force.



新中绿公司联系电话:0722-3308999
In the new company Tel: 0722-3308999